A defect that could cost dearly to 157,000 drivers

Renault, the big name of the automobile in France, is found at the moment with a series of massive reminders affecting several of its hybrid models. Consequently, These actions follow technical concerns of the hybrid system 1.6 E-Tech and at possible risks of fuel leaks. Similarly, This affair shows the technical problems that manufacturers may encounter when they incorporate new technologies.

Reliability broken for the hybrid system – Defect could cost dearly 157,000

Launched June 2020the hybrid system 1.6 E-Tech has been equipped on several flagship models of Renault, such as the Cliothe Megathe Captur and theArc. Furthermore, But, on vehicles manufactured until January 2024we noted worrying concerns in terms of the gearbox. For example, The main problem comes from a design defect in the toric seal of the hollow primary shaft of the electric motor. Furthermore, which lets the oil infiltrate the engine.

Symptoms can be seen defect could cost dearly 157,000 such as a loss of traction at start -up (sometimes the vehicle must be towed). an alert message for overheating the electric motor. To repair all of this. Renault launched a curative special technical operation (OTS) from the May 21, 2024specifically targeting the lost traction complaints and overheated engine.

Technical work. recall campaigns

For customers who have received an overheating message electric motor (DTC 0A9098 DTC code), Renault plans to dismantle the temperature sensor, replace the defective toric seal and completely clean the electric motor. In the event of a loss of traction at start -up (DTC 16D861 defect code). the gearbox must be replaced in full.

At the same time, Renault launched two separate campaigns to take care of these concerns. The first concerns 155 825 Hybrid vehicles made between September 2020. September 2022, and includes the Clio V, Captur II, Arkana and Mégane IV models. The main concern defect could cost dearly 157,000 here is linked to the control of the lubrication circuit of the hybrid gearbox. with replacement of the seal if necessary.

The second campaign specifically targets the Koleos model. produced between the September 19, 2019 and the September 18, 2023 in the Busan factory in Korea. With 2,901 units concernedthis intervention consists in replacing a defective fuel supply pipe which could cause dangerous leaks.

What should owners do?

In total, more than 157,595 vehicles could be affected by these reminders only in France. For customers with vehicles under the age of seven and having drove less than 150 000 kmthe maintenance is fully supported.

Renault specifies that even if these reminders are important. they are not comparable to the famous Takata Airbags reminders which had shaken the industry a few years ago. The owners will receive a letter indicating the steps to follow them. are invited to contact their dealer defect could cost dearly 157,000 to check if their vehicle is affected by these measures.